• <acronym id="lorcq"><em id="lorcq"><tt id="lorcq"></tt></em></acronym>

          <acronym id="lorcq"><em id="lorcq"><dfn id="lorcq"></dfn></em></acronym>

            <sub id="lorcq"></sub>

            1. <delect id="lorcq"><center id="lorcq"><wbr id="lorcq"></wbr></center></delect>
              山東山汽工程機械(集團)有限公司
              熱線電話:400-879-1999 山汽官方微信
              鄭重聲明 購機 售后
              在線詢價
              熱線電話:400-879-1999
              您現在所在的位置: 首頁> 新聞資訊 > 公司新聞 >

              攪拌車止油方法有哪些?

              所屬分類:公司新聞 發布時間:2022-03-31 來源:http://www.ikpipi.com 瀏覽量:18

              使用時間過長且油封是正常磨損情況。解決方案:更換油封即可。
              The service time is too long and the oil seal is normal wear. Solution: replace the oil seal.
              油長期未更換、濾芯質量不合格,油品過臟,從而讓油封磨損更快。解決方案:盡快更換液壓油、濾芯。
              The oil has not been replaced for a long time, the filter element quality is unqualified, and the oil is too dirty, which makes the oil seal wear faster. Solution: replace the hydraulic oil and filter element as soon as possible.
              傳動軸平衡失效,擺動量大,從而引起了主軸擺動油封偏磨。處理方案:及時糾正、更換轉動軸。
              The balance of the transmission shaft fails and the swing momentum is large, which causes the eccentric wear of the main shaft swing oil seal. Solution: correct and replace the rotating shaft in time.
              液壓油變質、乳化,從而導致潤滑性能下降,讓油封磨損更快。解決方案:盡快更換液壓油、濾芯,嚴重時需要清理系統。
              The deterioration and emulsification of hydraulic oil leads to the decline of lubrication performance and faster wear of oil seal. Solution: replace the hydraulic oil and filter element as soon as possible, and clean the system when it is serious.
              泵支架松動、開泵、泵固定螺栓松動,進而引起液壓泵出現整體抖動情況且油封出現磨損現象。解決方案:經常檢查并排除攪拌車中可能出現的故障,預防并避免故障的發生。
              The pump support is loose, the pump is opened, and the pump fixing bolts are loose, resulting in the overall shaking of the hydraulic pump and the wear of the oil seal. Solution: frequently check and eliminate the possible faults in the mixer truck to prevent and avoid the occurrence of faults..
              攪拌車止油方法有哪些?
              What are the methods of stopping oil in mixer truck?
              攪拌車系統的回油不通暢,回油管、散熱器發生堵塞,進而導致馬達殼中壓力增加,引起油封出現漏油情況。解決方案:排除堵塞并保持回油循壞保持通暢。
              The oil return of the mixer system is not smooth, and the oil return pipe and radiator are blocked, which leads to the increase of pressure in the motor shell and the oil leakage of the oil seal. Solution: remove the blockage and keep the oil return circulation unobstructed.
              攪拌車散熱器不散熱導致油溫過高,粘度、潤滑性下降,油封過熱密封失效等問題的出現。解決方案:排除散熱器故障,為系統進行降溫過程,避免泵馬達磨損。嚴重時還要停車熄火,用水沖泵馬達、散熱器殼體達到降溫效果。
              The radiator of the mixer truck does not dissipate heat, which leads to problems such as excessive oil temperature, decline in viscosity and lubricity, overheating of oil seal, seal failure and so on. Solution: eliminate the radiator failure and conduct the cooling process for the system to avoid the wear of the pump motor. In severe cases, stop the engine and flush the pump motor and radiator housing with water to achieve the cooling effect.
              冬季起車時若預熱不足,導致油溫過低,油液、油封未達到理想工作溫度。處理方案:在起車時停罐怠速運轉10min至20min,待油溫正常后再轉罐工作。
              When starting in winter, if the preheating is insufficient, the oil temperature is too low, and the oil and oil seal do not reach the ideal working temperature. Treatment scheme: stop the tank and idle for 10min to 20min when starting, and turn the tank to work after the oil temperature is normal.
              攪拌車的液壓泵軸端油封屬于易損件,若嚴格按照相關規范進行操作,其實很多漏油現象都會得到更好的預防,若出現漏油問題,要冷靜查找具體原因并進行處理即可。
              The oil seal at the shaft end of the hydraulic pump of the mixer truck is a vulnerable part. If it is operated in strict accordance with the relevant specifications, in fact, many oil leakage phenomena will be better prevented. In case of oil leakage, it is necessary to calmly find out the specific causes and deal with them.
              以上就是為大家介紹的有關全自動上料攪拌車的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.ikpipi.com/
              The above is a detailed introduction to the automatic feeding mixer truck. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.ikpipi.com/
              熱門產品 / HOT PRODUCT

               

              首頁 產品 電話 置頂
              无码专区y 6080电影视频
            2. <acronym id="lorcq"><em id="lorcq"><tt id="lorcq"></tt></em></acronym>

                    <acronym id="lorcq"><em id="lorcq"><dfn id="lorcq"></dfn></em></acronym>

                      <sub id="lorcq"></sub>

                      1. <delect id="lorcq"><center id="lorcq"><wbr id="lorcq"></wbr></center></delect>